Abstract
Nitromethane has a stoichiometric air–fuel ratio of 1.7, which is 8.5 times lower than gasoline. For the same amount of air being drawn by the engine, more amount of nitromethane blends and hence more energy can be added. Methanol was used as a medium to mix nitromethane and gasoline, which are normally immiscible. Engine performance tests were carried out to study the effect of nitromethane addition to the methanol-gasoline blend. A large rise in engine torque and brake thermal efficiency (BTE) was obtained during the investigation. However, the brake specific fuel consumption (BSFC) also increased for the nitromethane blends. The engine parameters like spark timing, equivalence ratio, and compression ratio were optimized to further increase the engine power and also bring down the BSFC. A net torque improvement of 42%, BTE improvement of 35%, and BSFC rise of 9% were obtained by adding nitromethane and methanol in small fractions to gasoline. Combustion analysis was carried out using the cylinder pressure trace. High heat release rate and shorter combustion duration with nitromethane addition were observed. Emission measurements showed decrease in HC and CO emissions with nitromethane addition. However, a drastic rise in NO emissions was observed. Hence, it can be concluded that the specific power of small two-stroke spark ignition (SI) engines can be enhanced using nitromethane as a fuel additive to increase the payload of the unmanned aerial vehicles.
Issue Section:
Research Papers
Topics:
Combustion,
Emissions,
Engines,
Fuels,
Gasoline,
Methanol,
Unmanned aerial vehicles,
Torque,
Compression,
Ignition,
Heat
References
1.
Valavanis
,
K. P.
, 2007
, Advances in Unmanned Aerial Vehicles: State of the Art and the Road to Autonomy
,
Springer
,
The Netherlands
.https://www.springer.com/gp/book/97814020611342.
Fernandez-Pello
,
A. C.
, 2002
, “
Micropower Generation Using Combustion: Issues and Approaches
,” Proc. Combust. Inst.
,
29
(1
), pp. 883
–899
.10.1016/S1540-7489(02)80113-43.
Sarangi
,
A. K.
,
Mehta
,
P. S.
, and
Ramesh
,
A.
, 2015
, “
Investigating Combustion in a Mini Internal Combustion Engine
,” SAE Int. J. Aerosp.
,
8
(1
), pp. 137
–149
.10.4271/2015-01-90024.
Starkman
,
E. S.
, 1954
, “
Nitromethane as a Piston Engine Fuel
,” SAE
Paper No. 540186.10.4271/5401865.
Raviteja
,
S.
,
Ramakrishna
,
P. A.
, and
Ramesh
,
A.
, 2019
, “
Performance Enhancement of a Small Two-Stroke Engine Using Nitromethane Blends
,” J. Propul. Power
,
35
(3
), pp. 520
–529
.10.2514/1.B371816.
Cirigliano
,
D.
,
Frisch
,
A. M.
,
Liu
,
F.
, and
Sirignano
,
W. A.
, 2018
, “
Diesel, Spark-Ignition, and Turboprop Engines for Long-Duration Unmanned Air Flights
,” J. Propul. Power
,
34
(4
), pp. 878
–892
.10.2514/1.B365477.
Ausserer
,
J. K.
,
Polanka
,
M. D.
,
Litke
,
P. J.
, and
Baranski
,
J. A.
, 2019
, “
Experimental Investigation of Fuel Anti-Knock-Index Requirements in Three Small Two-Stroke Engines for Remotely Piloted Aircraft
,” ASME J. Eng. Gas Turbines Power
, 141(5
), p. 051502
.10.1115/1.40405208.
Ausserer
,
J. K.
,
Polanka
,
M. D.
,
Litke
,
P. J.
, and
Baranski
,
J. A.
, 2019
, “
The Control Space for Knock Mitigation in Two-Stroke Engines for 10–25 kg Remotely Piloted Aircraft
,” ASME J. Eng. Gas Turbines Power
,
141
(9
), p. 091010
.10.1115/1.40437459.
Heywood
,
J. B.
, 1988
, Internal Combustion Engine Fundamentals
, McGraw-Hill, New York.10.
Balki
,
M. K.
,
Sayin
,
C.
, and
Canakci
,
M.
, 2014
, “
The Effect of Different Alcohol Fuels on the Performance, Emission and Combustion Characteristics of a Gasoline Engine
,” Fuel
,
115
, pp. 901
–906
.10.1016/j.fuel.2012.09.02011.
Popuri
,
S. S. S.
, and
Bata
,
R. M.
, 1993
, “
A Performance Study of Iso-Butanol-, Methanol-, and Ethanol-Gasoline Blends Using a Single Cylinder Engine
,” SAE
Paper No. 932953.10.4271/93295312.
Çelik
,
M. B.
,
Özdalyan
,
B.
, and
Alkan
,
F.
, 2011
, “
The Use of Pure Methanol as Fuel at High Compression Ratio in a Single Cylinder Gasoline Engine
,” Fuel
,
90
(4
), pp. 1591
–1598
.10.1016/j.fuel.2010.10.03513.
Bata
,
R. M.
, and
Roan
,
V. P.
, 1989
, “
Effects of Ethanol and/or Methanol in Alcohol-Gasoline Blends on Exhaust Emissions
,” ASME J. Eng. Gas Turbines Power
,
111
(3
), pp. 432
–438
.10.1115/1.324027214.
Al-Hasan
,
M.
, 2003
, “
Effect of Ethanol-Unleaded Gasoline Blends on Engine Performance and Exhaust Emission
,” Energy Convers. Manag.
,
44
(9
), pp. 1547
–1561
.10.1016/S0196-8904(02)00166-815.
Venugopal
,
T.
, and
Ramesh
,
A.
, 2013
, “
Effective Utilisation of Butanol Along With Gasoline in a Spark Ignition Engine Through a Dual Injection System
,” Appl. Therm. Eng.
,
59
(1–2
), pp. 550
–558
.10.1016/j.applthermaleng.2013.06.02616.
Rice
,
R. W.
,
Sanyal
,
A. K.
,
Elrod
,
A. C.
, and
Bata
,
R. M.
, 1991
, “
Exhaust Gas Emissions of Butanol, Ethanol, and Methanol-Gasoline Blends
,” ASME J. Eng. Gas Turbines Power
,
113
(3
), pp. 377
–381
.10.1115/1.290624117.
Osman
,
M. M.
,
Matar
,
M. S.
, and
Koreish
,
S.
, 1993
, “
Effect of Methyl Tertiary Butyl Ether (MTBE) as a Gasoline Additive on Engine Performance and Exhaust Emissions
,” Fuel Sci. Technol. Int.
,
11
(10
), pp. 1331
–1343
.10.1080/0884375930891613518.
Raine
,
R. R.
, and
Thorwarth
,
H.
, 2004
, “
Performance and Combustion Characteristics of a Glow-Ignition Two-Stroke Engine
,” SAE
Paper No. 2004-01–14.10.4271/2004-01–1419.
Germane
,
G. J.
, 1985
, “
A Technical Review of Automotive Racing Fuels
,” SAE
Paper No. 852129.10.4271/85212920.
Bush
,
K. C.
,
Germane
,
G. J.
, and
Hess
,
G. L.
, 1985
, “
Improved Utilization of Nitromethane as an Internal Combustion Engine Fuel
,” SAE
Paper No. 852130.10.4271/85213021.
Starkman
,
E. S.
, 1959
, “
Nitroparaffins as Potential Engine Fuel
,” Ind. Eng. Chem.
,
51
(12
), pp. 1477
–1480
.10.1021/ie50600a03522.
Daubert
,
T. E.
, and
Danner
,
R. P.
, 1989
, Physical and Thermodynamic Properties of Pure Chemicals: Data Compilation
,
Hemisphere Pub., Corp
.,
New York
.23.
Raviteja, S.
,
R.
, Ramakrishna,
P. A.
, and
Ramesh
,
A.
, 2018
, “
Laminar Burning Velocities of Nitromethane—Gasoline Blends at Elevated Temperatures and Pressures
,” ASME J. Energy Resour. Technol.
, 141(4), p. 042202
.10.1115/1.404172524.
Agarwal
,
A. K.
,
Karare
,
H.
, and
Dhar
,
A.
, 2014
, “
Combustion, Performance, Emissions and Particulate Characterization of a Methanol–Gasoline Blend (Gasohol) Fuelled Medium Duty Spark Ignition Transportation Engine
,” Fuel Process Technol.
,
121
, pp. 16
–24
.10.1016/j.fuproc.2013.12.01425.
Hayes
,
T. K.
,
Savage
,
L. D.
, and
Sorenson
,
S. C.
, 1986
, “
Cylinder Pressure Data Acquisition and Heat Release Analysis on a Personal Computer
,” SAE
Paper No. 860029.10.4271/86002926.
Taylor
,
J.
, 1997
, Introduction to Error Analysis, the Study of Uncertainties in Physical Measurements
, 2nd ed., University Science Books, Mill Valley, CA.27.
Pourkhesalian
,
A. M.
,
Shamekhi
,
A. H.
, and
Salimi
,
F.
, 2010
, “
Alternative Fuel and Gasoline in an SI Engine: A Comparative Study of Performance and Emissions Characteristics
,” Fuel
,
89
(5
), pp. 1056
–1063
.10.1016/j.fuel.2009.11.02528.
Huang
,
Y.
,
Sung
,
C. J.
, and
Eng
,
J. A.
, 2004
, “
Laminar Flame Speeds of Primary Reference Fuels and Reformer Gas Mixtures
,” Combust Flame.
,
139
(3
), pp. 239
–251
.10.1016/j.combustflame.2004.08.01129.
Faghih
,
M.
, and
Chen
,
Z.
, 2017
, “
Two-Stage Heat Release in Nitromethane/Air Flame and Its Impact on Laminar Flame Speed Measurement
,” Combust Flame.
,
183
, pp. 157
–165
.10.1016/j.combustflame.2017.05.01330.
Brequigny
,
P.
,
Dayma
,
G.
,
Halter
,
F.
,
Mounaïm-Rousselle
,
C.
,
Dubois
,
T.
, and
Dagaut
,
P.
, 2015
, “
Laminar Burning Velocities of Premixed Nitromethane/Air Flames: An Experimental and Kinetic Modeling Study
,” Proc. Combust. Inst.
,
35
(1
), pp. 703
–710
.10.1016/j.proci.2014.06.12631.
Pundir
,
B. P.
, 2010
, IC Engines: Combustion and Emissions
,
Alpha Science International
,
Oxford, UK
.Copyright © 2020 by ASME
You do not currently have access to this content.
